Diesel Generator Sets C175-20 (50 Hz) 3150 - 4000 kVA Diesel Generator Set

C175-20 (50 Hz) Standard Equipment

Air Inlet

• 4 x Single element canister air cleaners with service indicator(s).

Control Panel

• Engine cycle crank

• Oil pressure (psi, kPa or bar)

• Digital Indicators

• Coolant temperature

• Environmental sealed front face

• Frequency (Hz)

• True RMS AC metering, 3-phase, +/-2% accuracy

• Text alarm / event descriptions

• Low coolant level

• Volts (L-L & L-N)

• Auto / start / stop control

• Warning / shutdown indicators

• Emergency stop pushbutton

• Engine cool-down timer

• DC volts

• High coolant temperature

• Operating hours

• Low oil pressure

• EMCP 4.2B

• Amps (per phase & average)

• 4 Programmable relay Inputs

• Alarm acknowledge

• 4 Programmable relay output

• Failure to start (overcrank)

• Overspeed

• Lamp test

• 24 Volt DC operation

• Wall mounted controls

• RPM

Cooling System

• SCAC cooling

• Coolant sensors

• JW Inlet: 6" ANSI / JW Outlet: 5" Cat Flange

• AC Inlet: 6" ANSI / AC Outlet: 3-1/2" ANSI

Exhaust

• Dry exhaust manifold

• Bolted flange (ANSI 6" & DIN 150) with bellow for each turbo (Qty 4). 50 Hz

Fuel

• Filters x 3

• Secondary / tertiary fuel filters

• 4 Micron spin on type

• 10 Micron spin on type

• Engine mounted filters x 3

• Primary fuel filter water / fuel water separator

Generators and Attachments

• Salient Pole

• RFI suppression

• Anti condensation space Heater

• IEC Platinum Stator RTDs

• Form wound

• NEMA Class H insulation

• Voltage regulator:

• Reactive droop capability

• Min/max Exciter limiter

• 3 Phase voltage sensing

• Exciter diode monitor

• 6 Leads

• 3 Phase brushless

• Right side extension box, bottom cable entry

• Permanent magnet

• Class H temperature rise at 40C ambient

Governing System

• ADEM A4

• Redundant Shutdown (Overspeed protection through a duplicate speed sensing system)

Lube System

• Oil drain lines and valve

• Gear type lube oil pump

• Oil filter, filler and dipstick

• Integral lube oil cooler

• Lubricating oil

• Fumes disposal

Mounting Systems

• Rails - Engine / Generator

• Rubber anti-vibration mounts (shipped loose)

Starting / Charging System

• Batteries and battery rack w/cables

• Dual 24 volt electric starting motors

• Battery disconnect switch

General

• SAE standard rotation

• Right hand service

• Paint - Caterpillar Yellow with high gloss black rails

C175-20 (50 Hz) Optional Equipment

Air Inlet Systems

• Single element air cleaner

Control Panels

• EMCP 4.3 and EMCP 4.4

• EMCP and MV and HV power connection locations

• Load share module

• EMCP voltage and current sensing groups

• Speed adjust

• Annunciator modules

• Customer interface options

• Generator temperature monitoring

• E-Stop

• Interconnect harness

• Generator harness

• Modbus monitoring of packages

• Vandal proof panel door

Cooling System

• Package mounted radiators

• Remote radiators

• Fuel cooler

Crankcase Systems

• Explosive relief valves

• Crankcase ventilation system

Exhaust System

• Front housing - Standby or mission critical

• Front housing - Prime or continuous

• Exhaust collectors / Manifold

• Mufflers (15, 25 and 34 dBA)

Fuel System

• Primary fuel filter

Generators and Attachments

• Medium voltage - 3000 Frames - 50 Hz, 3 phase, 1500 rpm, FW, PM, No of leads=6, Pitch 0.6667

• Thermostat for space heater

• Generator air cleaner

• Differential current transformers - (5, 9 and 15 kV Class)

Instrumentation

• Pyrometer and thermocouples

Lube System

• Lube oil heater

• Lube oil heater with crankcase explosion relief valve

• Drain group oil pans

• Lubricating oil

• Electric prelube pumps

• Oil filters

Mounting System

• Rubber anti-vibration mounts

• Spring type linear vibration isolators

• IBC vibration isolators - Shipped loose

Special Tests / Reports

• Generator test report

• PGS test report @ 1.0 power factor

• PGS test report @ 0.8 power factor

• Standard genset TVA (Torsional Vibration Analysis) report

• Custom genset TVA report

• Special test charge - Engine only

• Genset fuel consumption test

• Standard engine test charge

Starting / Charging System

• 24 Volt electric starting motors

• Air starting motor

• Air pressure regulator

• Starter location covers

• 24 Volt battery sets - Dry

• 20, 35 and 50 Amp battery chargers

• Charging alternators - Dry

• Jacket water heaters

General

• Special paint - 3500, Colors (other than Caterpillar yellow) or high performance paints

• US aid emblem

• Service tools

• Engine barring group

• Manual

• Engine barring air powered

• control GP - Air powered bar group